Overdrive Transmissions – The Top 5 Advantages


Prior to the 1980s, most domestic cars and light trucks had transmissions with a 1:1 ratio in high gear, which means that the car’s driveshaft will turn the same speed as the engine. This 1:1 ratio served us well for fifty years or more. As oil prices rose and the country as a whole became increasingly concerned about the amount of air pollution coming from our vehicles, automakers began to look towards overdrive transmissions as part of the solution.

With an overdrive transmission, the top gear is less than a 1:1 ratio, which means that the driveshaft will turn at a faster speed than the engine. For example, if you have a car without overdrive and a 1:1 top gear ratio, a 3.08 axle ratio, and a 26″ tall tire, your engine speed at 70 MPH is about 2750 RPM. The typical overdrive in a domestic car is about a 0.70:1 ratio, which means that in top gear the driveshaft will turn 42.9% faster than engine speed (1 divided by 0.70 = 1.429). In the same car with an overdrive transmission and a 0.70:1 top gear ratio, engine speed at 70 MPH is reduced to 1925 RPM! That is 825 fewer RPM, a reduction of almost one-third.

This reduction in engine speed has several advantages:

1.) Lower fuel consumption – on the highway, your engine will use roughly one-third less fuel.
2.) Lower emissions – on the highway, your engine will emit roughly one-third less pollution.
3.) Longer engine life – all other things being equal, your engine theoretically has a life that consists of a certain number of revolutions. You are going the same distance as before, but using fewer of those revolutions to get there.
4.) Longer accessory life – your water pump, alternator, power steering pump, A/C compressor, and smog pump (if equipped) are all turning at a lower RPM and should last longer.
5) Less cabin noise – an engine turning at a lower RPM will be quieter, making the trip less stressful. It is easier to have a conversation, and you can actually hear the radio!

There are a few minor trade-offs, though. The engine will have less power for passing and going up hills when the transmission is in high gear, so downshifting will be necessary at times. Most overdrive transmissions are slightly heavier than their non-overdrive counterparts, too, but this difference is negligible in most cases.

All in all, overdrive transmissions have been one of the biggest improvements to be made to domestic cars in the last thirty years. They have made a larger difference in highway fuel economy than fuel injection and computerized engine controls. There are a number of companies such as Keisler Engineering that have made a good business out of providing overdrives to retrofit into classic musclecars and street rods! Given the advantages of overdrive transmissions, my biggest question is why the automakers didn’t offer them sooner!

Leave a Reply

Next Post

Car Rental In Muscat - A Few Things You Ought To Know Before You Take The Road

When in Muscat, renting a car can save you a lot of commuting time and hassles. However, before you go make sure that you understand the traffic rules and driving prerequisites demanded by the Roman Oman Police (ROP). Driving License And Insurance Requirements If you are on a short-term visit, […]
Car Rental In Muscat – A Few Things You Ought To Know Before You Take The Road

You May Like